TM 9-2330-390-14&P
Table 4-2. Unit Troubleshooting (Con't).
MALFUNCTION
TEST OR INSPECTION
CORRECTIVE ACTION
21. ENGINE TURNS OVER BUT WILL NOT START
Diesel fuel is combustible. DO NOT smoke or allow an open flame near fuel tank. Shut
down engine when adding fuel. Failure to follow this warning will result in serious injury
or death to personnel. If you are burned, immediately seek medical attention.
Step 1.
Remove cap from fuel tank (see paragraph 4-125). Check for clogged vent in cap.
Clean or replace damaged cap (see paragraph 4-125).
Step 2.
Check fuel lines for leaks, clogging, or damage.
Tighten or replace damaged fuel lines (see paragraph 4-122).
If NBC exposure is suspected, ail engine air cleaner air filter media should be handled
by personnel wearing protective equipment. Consult your NBC Officer or NBC NCO
for appropriate handling or disposal procedures.
Step 3.
Check for clogged air cleaner element (see paragraph 4-123).
Clean or replace damaged air cleaner element (see paragraph 4-123).
Step 4.
Remove side cover (see paragraph 4-126). Inspect speed control lever and stop lever for free
movement and signs of damage.
Clean speed control lever and stop lever, and lubricate with lubricating oil (Item 23,
Appendix F) as required.
If levers are frozen or damaged, notify Direct Support Maintenance.
4-43